Servicios Personalizados
Revista
Articulo
Indicadores
- Citado por SciELO
- Accesos
Links relacionados
- Similares en SciELO
Compartir
Journal of applied research and technology
versión On-line ISSN 2448-6736versión impresa ISSN 1665-6423
J. appl. res. technol vol.8 no.3 Ciudad de México dic. 2010
Experimental Evaluation of Sugar Cane Bagasse Storage in Bales System
J. LoisCorrea*1, A. FloresVela2, D. OrtegaGrimaldo3, J. BermanDelgado4
1,2,3,4 Research Center of Applied Science and Advanced Technology (CICATAIPN), National Polytechnic Institute, Unit Altamira, km.14.5 Road TampicoIndustrial Port Altamira, C.P. 89600 Altamira, Tamaulipas, México. *Email: joralois@yahoo.com
ABSTRACT
An experimental evaluation was carried out on three bagasse storage piles with the following characteristics: wet baled raw bagasse, wet baled depithed bagasse and predried baled depithed bagasse. In each of these formerly mentioned alternatives, the storage time influence was analyzed on temperature profile, humidity behavior, granulometry and morphology, with and without mechanical treatment, solubility in hot water, NaOH and alcoholbenzene extractives. In the same way, the behavior of brightness in mechanical pulps produced from stored bagasse was studied. Storage losses were calculated for each alternative on the basis of obtained results and it was demonstrated that predried bagasse as compared with wet bagasse storage, yields lower losses and better conservation of its characteristics.
Keywords: Bagasse, depithing, storage, bales system, cellulose, pentosans, lignin, losses.
RESUMEN
Una evaluación experimental se llevó a cabo en tres pilas de almacenamiento de bagazo con las siguientes características: bagazo integral empacado en húmedo, bagazo desmedulado empacado en húmedo y bagazo desmedulado empacado presecado. En cada una de las alternativas anteriormente mencionadas, se analizó la influencia del tiempo de almacenamiento sobre el perfil de temperatura, el comportamiento de la humedad, la granulometría y morfología, con y sin tratamiento mecánico, la solubilidad en agua caliente, en NaOH y Extractos AlcoholBenceno. De la misma manera, se estudió el comportamiento de la brillantez en las pulpas mecánicas producidas a partir del bagazo almacenado. Sobre la base de los resultados obtenidos, se calculó para cada alternativa las pérdidas por almacenamiento y se demostró que el presecado de bagazo en comparación con los rendimientos de almacenamiento húmedo rinde menores pérdidas y una mejor conservación de sus características.
DESCARGAR ARTÍCULO EN FORMATO PDF
References
[1] Narendra, R. and Y. Yang. Biofibers from agricultural byproducts for industrial applications. Trends in Biotechnology, 2005, Volume 23, Issue 1, January, pp.2227 [ Links ]
[2] Lois, J. Sugar cane and coproducts. Proceedings of XXXII ATAM Convention, 2009, Cordoba, Veracruz, August. [ Links ]
[3] Galvez, L. The Development of Sugar Cane ByProducts in Cuba, 1st International ISSCT Workshop on Sugar Cane ByProducts, 1994, pp. 2338, Havana, Cuba, March. [ Links ]
[4] Banerjee, R. and Pandey, A. Bioindustrial application of sugarcane bagasse: a technology perspective, 2002, Int. Sugar Journal, 1, pp.37. [ Links ]
[5] Kirchhoff, V. W. J. H. As queimadas da cana. São José dos Campos: Transtec Editorial. IN: Sustainability: use of sugarcane bagasse and bamboo leaves to produce sealing boards, 1991, POMS 20th Annual Conference Orlando, Florida U.S.A. May 1 to May 4, 2009. [ Links ]
[6] De Armas, C. Comments about cogeneration in the sugar industry. Proceedings of International Seminar on Commercial Energy Generation in the Cane Agroindustry, 1994, GEPLACEA, ASAZGUA and GTZ. Guatemala, June. [ Links ]
[7] Schmidt, O. and Walter, K., Sucession and Activity of Microorganisms in Stored Bagasse, European J. Appl. Microbiology and Biotechnology, SpringerVerlag, 1978, pp. 6977, Berlin, Germany. [ Links ]
[8] Lois, J., Storage of Bagasse for Derivatives Industries, Monograph, Editorial CientíficoTécnica, 1982, pp. 1327, Havana, Cuba (in spanish). [ Links ]
[9] Lacey, J. Moulding of sugar cane bagasse. Annals of applied biology, 2008, Volume 76, Issue 1 pp 6376. [ Links ]
[10] Atchison, J.E., Making Bagasse Available, XVI Congress of ISSCT, 1977, pp. 5466, South Africa. [ Links ]
[11] Lois, J. Bagasse Storage for Industrial Use, International Seminar on Commercial Energy Generation in the Cane Agroindustry GEPLACEA, ASAZGUA and GTZ, 1994, Guatemala City, Guatemala, April. [ Links ]
[12] Lois, J. et al, Experimental Evaluation of Bagasse Stored in Wet Bales in the Bagasse Boards Factory PROCUBA, 43 rd Congress of Cuban Association of Sugar Technicians ATAC, 1979, Havana, Cuba (in spanish). [ Links ]
[13] Lois, J. Storage of Bagasse for its Industrial Utilization in Cuba, Ph.D. Thesis, 1982, University of Zvolen, Slovaquia. [ Links ]
[14] Lois, J. and Suarez, R., Experimental Evaluation of Bagasse Storage in Bale System, XVIII Congress ISSCT, 1983, pp. Havana, Cuba. [ Links ]
[15] Nakasone, H. and Oda, K., Studies on Bagasse Storage. Deterioration of bagasse particle boards, Wood Ind. 31 (3), 1976. pp. 104107. [ Links ]