Serviços Personalizados
Journal
Artigo
Indicadores
-
Citado por SciELO
-
Acessos
Links relacionados
-
Similares em SciELO
Compartilhar
Revista mexicana de ingeniería química
versão impressa ISSN 1665-2738
Rev. Mex. Ing. Quím vol.8 no.1 Ciudad de México Abr. 2009
Ingeniería ambiental
Efecto de las cargas hidráulica y orgánica sobre la remoción masica de un empaque estructurado en un filtro percolador
Effect of hydraulic and organic loads on the mass removal of a structured packing in a trickling filter
S. ReyesLara y R. ReyesMazzoco*
Departamento de Ingeniería Química y de Alimentos, Universidad de las Américas, Puebla.
Recibido 27 de Octubre 2008
Aceptado 17 de Febrero 2009
Resumen
Se realizó un estudio a escala de banco del comportamiento de un nuevo empaque plástico estructurado para un filtro percolador que se diseñó siguiendo el modelo del módulo de Thiele para aumentar su eficiencia de remoción de contaminantes presentes en el agua. Para determinar la remoción másica de DQO del sistema operando en estado estable se aplicaron distintas cargas orgánicas, (L, kg DQO/m3s), e hidráulicas, (Q, m3/m2 d), de acuerdo a un diseño factorial de experimentos y dos tipos de agua residual. Se probaron valores de L entre 5 y 72 kg DQO/m3 d, más de diez veces mayores a los normalmente utilizados en filtros percoladores para depuración de aguas sanitarias, para demostrar que el diseño del empaque es capaz de manejarlos. La remoción másica se obtuvo entre 3 y 10 kg DQO/m3 d sin limitación en la transferencia de oxígeno. Usando el modelo cinético propuesto por Eckenfelder basado en L y en el área específica del empaque, la depuración del agua residual sintética produjo un valor de la constante cinética de 0.0423 kg DQO/m2 d y el agua residual preparada con suero de leche de 0.0867 kg DQO/m2 d.
Palabras clave: filtro percolador, carga orgánica, carga hidráulica, empaque estructurado.
Abstract
A bench scale study was performed on the behavior of a new structured packing for a trickling filter designed from the model of Thiele's modulus for increasing the removal efficiency of pollutants present in wastewater. For determining the mass removal of COD from the system working at steady state, several organic, (L, kg DQO/m3s), and hydraulic loads, (Q, m3/m2 d), were applied according to a factorial experimental design and two types of wastewater. L values were tested in the range of 5 to 72 kg DQO/m3 d, more than ten times higher than values used in sanitary wastewater treatment, to demonstrate that the packing's design is able to handle them. Mass removal was obtained from 3 to 10 kg DQO/m3 d with no limitation of oxygen transfer. Using the kinetic model proposed by Eckenfelder based on L and the specific area of the packing, the treatment of synthetic wastewater produced a value of the kinetic constant of 0.0423 kg DQO/m2 d and for the wastewater prepared from whey was 0.0867 kg DQO/m2 d.
Keywords: trickling filter, organic load, hydraulic load, structured packing.
DESCARGAR ARTÍCULO EN FORMATO PDF
Referencias
Amézquita Serrano, B.E. (2003) Estudio del desempeño de un filtro percolador con empaque estructurado. Tesis Licenciatura, Universidad de las Américas, Puebla. [ Links ]
Beyenal, H., and Lewandowski, Z. (2000) Combined Effect of Substrate Concentration and Flow Velocity on Effective Diffusivity in Biofilms. Water Resources 34(2) 528538. [ Links ]
Chipperfield P.N.J. (1967). Performance of Plastic Filter Media in Industrial and Domestic Waste Treatment. Journal of Water Pollution Control Federation 39, 18601874 [ Links ]
Clescerl, L. S., Greenberg, A. E., Eaton, A. D. (1999) Standard Methods for the Examination of Water and Wastewater, 20th Ed., APHA [ Links ]
Design Expert v 6.0.6 (2002) Statease, Inc. [ Links ]
Eding, E.H., Kamstra, A., Verreth, J.A.J., Huisman, E.A., and Klapwijk, A. (2006) Design and operation of nitrifying trickling filters in recirculating aquaculture: A review. Aquacultural Engineering 34, 234260 [ Links ]
Eckenfelder, W.W (1980). Principles of water quality management. CBI Publishing Co., Inc., Boston, Massachusetts [ Links ]
Gray, N.F., Learner, M.A. (1983) A pilotscale percolating filter for use in sewage treatment studies. Water Resources 17, 249253. [ Links ]
GonzálezBrambila, M. y LópezIsunza F. (2007) Transporte de masa y reacción en una biopelícula. Revista Mexicana de Ingeniería Química 6,127136. [ Links ]
GonzálezBrambila, M. y LópezIsunza F. (2008) Comportamiento de un reactor de biopelícula para tratamiento de agua residual a diferentes velocidades de flujo. Revista Mexicana de Ingeniería Química 7, 183193. [ Links ]
Gromiec, M.J., Malina, J.F., Eckenfelder, W.W. (1972) Performance of plastic medium in trickling filters. Water Resources 6, 13211332. [ Links ]
Jin Y., Veiga M. C., and Kennes C. (2007) Co treatment of hydrogen sulfide and methanol in a singlestage biotrickling filter under acidic conditions. Chemosphere 68, 11861193 [ Links ]
Kim, S., and Deshusses, M. A. (2008) Determination of mass transfer coefficients for packing materials used in biofilters and biotrickling filters for air pollution control. 1. Experimental results. Chemical Engineering Science 63, 841855. [ Links ]
Mathur, A. K. and Majumder, C.B. (2008) Biofiltration and kinetic aspects of a biotrickling filter for the removal of paint solvent mixture laden air stream. Journal of Hazardous Materials 152, 10271036. [ Links ]
Metcalf & Eddy (2003) Wastewater Engineering. Treatment and Reuse. 4th Ed. New York McGrawHill, Inc. [ Links ]
Randall A. A, Sullivan J.M., Dietz J., Randall, C.W. (1997) Industrial Pretreatment: Trickling filter performance and design. Journal of Environmental Engineering 123, 10721079 [ Links ]
Séguret F., Racault Y., and Sardin M. (2000) Hydrodynamic behavior of full scale trickling filters. Water Resources 34, 15511558. [ Links ]
Seignez C, Adler N, Thoeni C, Stettler M, Péringer P, and Holliger C. (2004) Steadystate and transientstate performance of a biotrickling filter treating chlorobenzenecontaining waste gas. Applied Microbiology and Biotechnology 65, 3337. [ Links ]
Thörn, M., Mattsson, A., and Sörensson F., 1996, Biofilm development in a nitrifying trickling filter. Water Science and Technology 34, 8389. [ Links ]
Ulug S.E., Ucuncu A. (1992) Process Efficiency Characterization of Plastic Medium Trickling Filter. International Journal of Environmental Studies 42, 3140. [ Links ]
Wang Q. H., Zhang L., Tian S., Sun P. T., and Xie W. (2007) A pilotstudy on treatment of a waste gas containing butyl acetate, nbutyl alcohol and phenylacetic acid from pharmaceutical factory by biotrickling filter. Biochemical Engineering Journal 37, 4248. [ Links ]
Wik, T., Mattsson, A., Hansson, E., and Niklasson, C. (1995) Nitrification in a tertiary trickling filter at high hydraulic loads pilot plant operation and mathematical modelling. Water Science and Technology 32, 185192. [ Links ]
Zilli M., Converti A., Fava F, and Nicolella C. (2007) Control of 2chlorophenol vapour emissions by a trickling biofilter. Journal of Biotechnology 128, 654658. [ Links ]